PolyCast™

Version 1.0

Issue date: 07/29/2019

Revision date: 07/29/2019 SDS record number: CSSS-TCO-010-132060

1. Identification

Product name PolyCast™

Synonyms -

CAS # See section 3

Product code -

Product use 3D Printing Filament

Manufacturer/Supplier

Supplier(Manufacturer): JF Polymers (Suzhou) Co., Ltd.

Address: Building 6&7&11, No.2, Hai Cheng Road, Chang Shu Economic & Technological Development Zone, 215513, People’s Republic of China

Contact person(E-mail): [email protected]

Telephone: +86-512-52058005

Fax: -

Emergency telephone Number: +86-512-52058005

2. Hazard(s) identification

GHS classification

Physical hazards deifissalc toN

Health hazards deifissalc toN

Environmental hazards deifissalc toN

GHS label elements

Hazard Pictograms No hazard pictogram is used.

Signal word No signal word is used.

Hazard statement Not applicable.

Precautionary statement

Prevention Not applicable.

Response Not applicable.

Storage Not applicable.

Disposal Not applicable.

3. Composition / information on ingredients

This product does not contain hazardous ingredients above cut-off value according to HCS2012.

4. First-aid Measures

First aid procedures

Eye contact Flush with running water for at least 15 minutes. If irritation persists get medical attention.

Skin contact Wash thoroughly with soap and water. Get medical attention in the unlikely event that irritation persists.

Inhalation If breathed in, remove victim to fresh air and keep at rest in a position comfortable for breathing. If you feel unwell, seek medical attention.

Ingestion Immediate first aid is not likely to be required. A physician or poison control center can be contacted for advice.

Notes to physician Treat symptoms.

5. Fire-fighting measures

Flammable properties Not available.

Extinguishing media

Suitable extinguishing media Use water spray, alcohol resistant foam, dry powder or carbon dioxide to extinguish the fire.

Unsuitable extinguishing media Avoid using DC water to extinguish fire, so as to avoid material splashes and fire spread.

Firefighting equipment/instructions

In case of fire and/or explosion do not breathe fumes. Protective respirator with independent air supply. According to size of fire Full protection, if necessary.Dispose of contaminated extinction water according to official regulations.

Hazardous combustion products Carbon oxides, nitrogen oxides.

  1. Accidental release measures

Personal precautions

Use personal protective equipment. Ensure adequate ventilation. Remove all sources of ignition. Evacuate personnel to safe areas. Avoid contact with skin and eyes. For personal protection see section 8.

Environmental precautions Avoid disposing into drainage/sewer system or directly into the aquatic environment.

Methods for cleaning up Sweep up and shovel into suitable containers. Clean up affected area.

7. Handling and storage

Handling Ensure good ventilation/exhaustion at the workplace. Wash thoroughly after handling.

Storage Store in cool place. Keep container tightly closed in a dry and well-ventilated place.

8. Exposure controls / personal protection

Occupational exposure limits This mixture has no ingredients that have PEL, TLV, or other recommended exposure limit.

Biological limit values No biological exposure limits noted for the ingredient(s).

Appropriate engineering controls: Use in a well-ventilated area.

Individual protection measures, such as personal protective equipment:

Eye / face protection Chemical safety goggles.

Skin protection Wear suitable protective clothing to prevent skin exposure

Respiratory protection Suitable respiratory protective device recommended.

General hygiene Wash hands, forearms and face thoroughly after handling chemical products,

considerations

before eating, smoking and using the lavatory and at the end of the working period. Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing.

9. Physical and chemical properties

Appearance

Physical state Solid

Form Solid

Color Translucent

Odor Odorless

Material name: PolyCast™ SDS US

Version #:1.0 Revision date: 07-29-2019. Issue date: 07-29-2019. 2 / 5

Odor threshold Not available

pH Not available

Vapor pressure Not available

Melting point/Freezing point Not available

initial boiling point and boiling range Not available

Flash point Not available

Evaporation rate Not available

Flammability (solid, gas) Not available

Explosion limits Not available

Vapor density Not available

Density 1.08-1.10

Solubility (water) Insoluble

Partition coefficient Not available

Auto-ignition temperature Not available

Decomposition temperature Not available

Specific gravity Not available

Flammability limits in air, upper, %by volume Not available

Flammability limits in air, lower, % by volume Not available

VOC Not available

Percent volatile Not available

Other data

Viscosity Not available

Upper/lower explosive limits Not available

Surface tension Not available

10. Stability and reactivity

Chemical stability Material is stable under normal conditions.

Conditions to avoid Incompatible materials.

Incompatible materials Avoid contact with other chemicals, oxidizing agents, strong alkalis and strong acids.

Hazardous decomposition products Carbon oxides, nitrogen oxides.

Possibility of hazardous reactions No dangerous reactions known.

11. Toxicological information

Toxicokinetics, metabolism and distribution:

Non-human toxicological data: Not available

Information on toxicological effects:

Acute toxicity:

LD50(Oral, Rat): Not available

LD50(Dermal, Rat): Not available

LC50(Inhalation, Rat): Not available

Skin corrosion/Irritation: Not classified.

Serious eye damage/irritation: Not classified

Respiratory or skin sensitization: Not classified

Germ cell mutagenicity: Not classified

Carcinogenicity: Not classified

Reproductive toxicity: Not classified

STOT- single exposure: Not classified

STOT-repeated exposure: Not classified

Aspiration hazard: Not classified

12. Ecological information

Toxicity:

Acute toxicity
Acute toxicity
Time
Species
Method
Evaluation
Remarks

EC50

N/A

72h

Fish

OECD 203

N/A

N/A

EC50

N/A

48h

Daphnia

OECD 202

N/A

N/A

EC50

N/A

72h

Algae

OECD 201

N/A

N/A

Persistence and degradability: Not available.

Bioaccumulative potential: Not available.

Mobility in soil: Not available.

Results of PBT&vPvB assessment: Not available.

Other adverse effects: No known significant effects or critical hazards.

13. Disposal considerations

Disposal instructions Dispose of contents/container in accordance with

local/regional/national/international regulations.

Contaminated packaging Since emptied containers may retain product residue, follow label warnings even after container is emptied.

14. Transport information

DOT

Basic shipping requirements:

UN number Not regulated

Proper shipping name Not regulated

Hazard class Not regulated

Packing group Not regulated

Environmental hazards No

IATA

UN number Not regulated

UN proper shipping name Not regulated

Transport hazard class(es) Not regulated

Packing group Not regulated

Environmental hazards No

IMDG

UN number Not regulated

UN proper shipping name Not regulated

Transport hazard class(es) Not regulated

Packing group Not regulated

Environmental hazards No

15. Regulatory information

US federal regulations

Toxic Substances Control Act (TSCA)

TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)

.detaluger toN

CERCLA Hazardous Substance List (40 CFR 302.4)

.detsil toN

SARA 304 Emergency release notification

.detaluger toN

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1053)

.detaluger toN

Superfund Amendments and Reauthorization Act of 1986 (SARA)

SARA 302 Extremely hazardous substance

.detsil toN

SARA 311/312 Hazardous chemical No

SARA 313 (TRI reporting)

Not regulated.

Other federal regulations

Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List

Not regulated.

Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)

Not regulated.

Safe Drinking Water Act (SDWA) Not regulated.

  1. Other information, including date of preparation or last revision

HMIS®ratings Health: 0

Flammability: 1

Physical hazard: 0

NFPA ratings Health: 0

Flammability: 1

Instability: 0

Disclaimer The information in the sheet was written based on the best knowledge and experience currently available.

Issue date 07-29-2019

Author: Hangzhou C&K Testing Technic Co.,Ltd Website:www.cirs-ck.com Tel:0571-89900715 Email:[email protected]

Last updated

Was this helpful?